Jump to content
2024 Houston Open WITB Photos ×

Basic Clubmaking


GolfWRX

Recommended Posts

Swing-Weights, Counter Balancing & MOI:
Swing-Weights, Counter Balancing & MOI: Part 1



Article by Paul Smith

There are three hot topics of conversation at this moment in time when it comes to how to build a golf club. Swing Weights, Counterbalancing and MOI (Moment of Inertia).

In Part One we will address the old school method of matching the feel of a club via its Swing Weight and follow on with just a brief look at Counter Balancing which is gaining some influence in the US market. Part Two will look at what MOI actually is and how it potentially changes clubmakers views on Swing Weighting clubs.

Swing Weights
Clubs have traditionally been measured on a Swing Weight gauge. This device allows us to measure the total club head feel in order to achieve a continuity amongst our clubs.

Low lofted irons start off lightest in weight (eg. A 3 iron head may weigh 240g) and because they have longer shafts they seem heavier in your hands due to the greater leverage effect. The higher the iron number the heavier the clubhead (eg a pitching wedge may weigh 290g) because the shorter shafts require a heavier head to continue the relative feel. Historically the only exception to the rule has been the Sand Wedge. Its job has been to plough into and throw a pad of sand and lift the ball up. The heavier head has always felt better to do this more strenuous job.

Historically steel shafted (125 gram) irons have been measured around a D0-D1 mark on a Swing Weight Gauge. Graphite shafts (60-90 gram) have a much lower total club weight therefore swing weights and head combinations have dropped to as low as C4-C5. The higher the letter and number the more you can feel the head of the club. So you will feel a D0 clubhead more than a C4.


Fig 1
7_1.jpg
Swing Weight reading for a Steel-shafted Iron


Fig 2
7_2.jpg
Swing Weight reading for a Graphite Iron


Fig 3
7_3.jpg
Weight & plugs on left are worth 1 point, on the right 2 points.





As a result, in the early days of lightweight graphite shafts many players may have shied away from them as they lost the feel for where their clubhead was going.

Swing Weights can be raised to allow for more clubhead feel by adding some weight, either down the shaft using lead powder, at the bottom of the shaft using a lead plug, stuck to the clubhead using lead tape or at the base of the hosel using a weight port filled with lead.

Each mark on the Swing Weight Gauge corresponds to approximately 2 grams in weight. Given that graphite shafts are almost half the weight of a steel shaft there is plenty of room to add weight to a clubhead.

Players blind tested cannot usually tell the difference of a 1 point Swing Weight change but many can tell a 2 point change (Fig. 3 above).

All of these changes deal with the feel of the club to the player. Higher Swing Weights may help players with faster tempos to control their initial downswing a little better. Slower tempo players may prefer a lighter Swing Weight however there is nothing wrong with them also having a higher reading on their clubs if they like that feel.

In all cases the ideal is that all a player's clubs are within a Swing Weight point of each other so that they all feel the same.

Swing Weights for drivers and fairway woods vary considerably especially since the advent of super light-weight shafts. This is something to keep in mind if you are thinking of changing the shaft in your driver as you may need to change the weight of the head to maintain its feel.

Counter Balancing
There has long been a school of thought that the ideal club would be weightless. The logic being that something weighing less is easier to move than something heavy. However, there are many practical issues with a weightless club feel in relation to what is actually happening with the club. For example, designs such as the 1980's Featherlites never sold well as the heads were so light that players could not control the clubs.

In most cases to increase clubhead feel, more swing-weight points are added to the clubhead. As we have demonstrated this involves adding just a few grams to the head end of the shaft or lead tape to the head itself. However, there is a school of thought that to increase the overall feel of the club you can increase the total weight of the club at the butt end. Counter balancing see us adding weights near the grip.

This may seem a little strange as it will indeed reduce the Swing Weight of the club. Tour players in the US have tried this method and found it has helped their game, especially with their drivers which contain such light weight shafts these days. But how would this approach help the average player?

Researchers at Golfsmith recently conducted a test with 15 players with an average Handicap of 11.5, an average age of 35 and an average swing speed of 95 mph. Five test clubs were built to the same specs apart from differing counter balanced weights in the grips. To cut a long story short, each player improved length off the tee. It may not have been the same weight in the club for each player that went furthest but each player found one weight that suited their swing better. I am sure there will be more research to come on this topic.

Putters seem to benefit a lot from Counter Balancing. The increased total weight of the club gives more overall feel and players often notice a marked increase in their sense of what is going on with the putter in their hands.

So Swing Weights and Counter Balancing are all about feel and there is no cut and dried answer to what will work for each player. There is a feel they will like and as a clubmaker it is our role to open up the possibilities.
Link to comment
Share on other sites

  • Replies 2
  • Created
  • Last Reply

Top Posters In This Topic

  • 5 months later...

I have a Cleveland 900 56* sand wedge and a Cleveland CG10 Black Pearl 60* lob wedge. I like the weighting on my sand wedge, I know my lob wedge has a swingweight of D6 but it feels lighter. I'm not sure what the swingweight on the sand wedge is. Where could I put lead tape on the lob wedge to get it to feel heavier?

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Recently Browsing   0 members

    • No registered users viewing this page.
  • Our picks

    • 2024 Texas Children's Houston Open - Discussion and links to Photos
      Please put any questions or Comments here
       
       
       
      General Albums
       
      2024 Texas Children's Houston Open - Monday #1
      2024 Texas Children's Houston Open - Monday #2
      2024 Texas Children's Houston Open - Tuesday #1
      2024 Texas Children's Houston Open - Tuesday #2
      2024 Texas Children's Houston Open - Tuesday #3
       
       
       
       
      WITB Albums
       
      Thorbjorn Olesen - WITB - 2024 Texas Children's Houston Open
      Ben Silverman - WITB - 2024 Texas Children's Houston Open
      Jesse Droemer - SoTX PGA Section POY - WITB - 2024 Texas Children's Houston Open
      David Lipsky - WITB - 2024 Texas Children's Houston Open
      Martin Trainer - WITB - 2024 Texas Children's Houston Open
      Zac Blair - WITB - 2024 Texas Children's Houston Open
      Jacob Bridgeman - WITB - 2024 Texas Children's Houston Open
      Trace Crowe - WITB - 2024 Texas Children's Houston Open
      Jimmy Walker - WITB - 2024 Texas Children's Houston Open
      Daniel Berger - WITB(very mini) - 2024 Texas Children's Houston Open
      Chesson Hadley - WITB - 2024 Texas Children's Houston Open
      Callum McNeill - WITB - 2024 Texas Children's Houston Open
      Rhein Gibson - WITB - 2024 Texas Children's Houston Open
      Patrick Fishburn - WITB - 2024 Texas Children's Houston Open
      Peter Malnati - WITB - 2024 Texas Children's Houston Open
      Raul Pereda - WITB - 2024 Texas Children's Houston Open
      Gary Woodland WITB (New driver, iron shafts) – 2024 Texas Children's Houston Open
      Padraig Harrington WITB – 2024 Texas Children's Houston Open
       
       
       
       
      Pullout Albums
       
      Tom Hoge's custom Cameron - 2024 Texas Children's Houston Open
      Cameron putter - 2024 Texas Children's Houston Open
      Piretti putters - 2024 Texas Children's Houston Open
      Ping putter - 2024 Texas Children's Houston Open
      Kevin Dougherty's custom Cameron putter - 2024 Texas Children's Houston Open
      Bettinardi putter - 2024 Texas Children's Houston Open
      Cameron putter - 2024 Texas Children's Houston Open
      Erik Barnes testing an all-black Axis1 putter – 2024 Texas Children's Houston Open
      Tony Finau's new driver shaft – 2024 Texas Children's Houston Open
       
       
       
       
       
      • 9 replies
    • 2024 Valspar Championship WITB Photos (Thanks to bvmagic)- Discussion & Links to Photos
      This weeks WITB Pics are from member bvmagic (Brian). Brian's first event for WRX was in 2008 at Bayhill while in college. Thanks so much bv.
       
      Please put your comments or question on this thread. Links to all the threads are below...
       
       
       
       
        • Like
      • 31 replies
    • 2024 Arnold Palmer Invitational - Discussion and Links to Photos
      Please put any questions or comments here
       
       
       
      General Albums
       
      2024 Arnold Palmer Invitational - Monday #1
      2024 Arnold Palmer Invitational - Monday #2
      2024 Arnold Palmer Invitational - Monday #3
       
       
       
       
      WITB Albums
       
      Matt (LFG) Every - WITB - 2024 Arnold Palmer Invitational
      Sahith Theegala - WITB - 2024 Arnold Palmer Invitational
       
       
       
       
       
      Pullout Albums
       
      New Cameron putters (and new "LD" grip) - 2024 Arnold Palmer Invitational
      New Bettinardi MB & CB irons - 2024 Arnold Palmer Invitational
      Custom Bettinardi API putter cover - 2024 Arnold Palmer Invitational
      Custom Swag API covers - 2024 Arnold Palmer Invitational
      New Golf Pride Reverse Taper grips - 2024 Arnold Palmer Invitational
       
       
       
       
       
       
       
        • Like
      • 15 replies
    • 2024 Cognizant Classic - Discussion and Links to Photos
      Please put any questions or comments here
       
       
       
       
      General Albums
       
      2024 Cognizant Classic - Monday #1
      2024 Cognizant Classic - Monday #2
      2024 Cognizant Classic - Monday #3
      2024 Cognizant Classic - Monday #4
       
       
       
      WITB Albums
       
      Brandt Snedeker - WITB - 2024 Cognizant Classic
      Max Greyserman - WITB - 2024 Cognizant Classic
      Eric Cole - WITB - 2024 Cognizant Classic
      Carl Yuan - WITb - 2024 Cognizant Classic
      Russell Henley - WITB - 2024 Cognizant Classic
      Justin Sun - WITB - 2024 Cognizant Classic
      Alex Noren - WITB - 2024 Cognizant Classic
      Shane Lowry - WITB - 2024 Cognizant Classic
      Taylor Montgomery - WITB - 2024 Cognizant Classic
      Jake Knapp (KnappTime_ltd) - WITB - - 2024 Cognizant Classic
       
       
       
      Pullout Albums
       
      New Super Stoke Pistol Lock 1.0 & 2.0 grips - 2024 Cognizant Classic
      LA Golf new insert putter - 2024 Cognizant Classic
      New Garsen Quad Tour 15 grip - 2024 Cognizant Classic
      New Swag covers - 2024 Cognizant Classic
      Jacob Bridgeman's custom Cameron putter - 2024 Cognizant Classic
      Bud Cauley's custom Cameron putters - 2024 Cognizant Classic
      Ryo Hisatsune's custom Cameron putter - 2024 Cognizant Classic
      Chris Kirk - new black Callaway Apex CB irons and a few Odyssey putters - 2024 Cognizant Classic
      Alejandro Tosti's custom Cameron putter - 2024 Cognizant Classic
       
       
       
       
       
       
       
       
        • Like
      • 2 replies
    • 2024 Genesis Invitational - Discussion and Links to Photos
      Please put any questions or comments here
       
       
       
      General Albums
       
      2024 Genesis Invitational - Monday #1
      2024 Genesis Invitational - Monday #2
      2024 Genesis Invitational - Tuesday #1
      2024 Genesis Invitational - Tuesday #2
      2024 Genesis Invitational - Tuesday #3
      2024 Genesis Invitational - Tuesday #4
       
       
       
       
      WITB Albums
       
      Rory McIlroy - WITB - 2024 Genesis Invitational
      Sepp Straka - WITB - 2024 Genesis Invitational
      Patrick Rodgers - WITB - 2024 Genesis Invitational
      Brendon Todd - WITB - 2024 Genesis Invitational
      Denny McCarthy - WITB - 2024 Genesis Invitational
      Corey Conners - WITB - 2024 Genesis Invitational
      Chase Johnson - WITB - 2024 Genesis Invitational
      Tiger Woods - WITB - 2024 Genesis Invitational
      Tommy Fleetwood - WITB - 2024 Genesis Invitational
      Matt Fitzpatrick - WITB - 2024 Genesis Invitational
      Si Woo Kim - WITB - 2024 Genesis Invitational
      Viktor Hovland - WITB - 2024 Genesis Invitational
      Wyndham Clark - WITB - 2024 Genesis Invitational
      Cam Davis - WITB - 2024 Genesis Invitational
      Nick Taylor - WITB - 2024 Genesis Invitational
      Ben Baller WITB update (New putter, driver, hybrid and shafts) – 2024 Genesis Invitational
       
       
       
       
       
      Pullout Albums
       
      New Vortex Golf rangefinder - 2024 Genesis Invitational
      New Fujikura Ventus shaft - 2024 Genesis Invitational
      Tiger Woods & TaylorMade "Sun Day Red" apparel launch event, product photos – 2024 Genesis Invitational
      Tiger Woods Sun Day Red golf shoes - 2024 Genesis Invitational
      Aretera shafts - 2024 Genesis Invitational
      New Toulon putters - 2024 Genesis Invitational
      Tiger Woods' new white "Sun Day Red" golf shoe prototypes – 2024 Genesis Invitational
       
       
       
       
       
      • 22 replies

×
×
  • Create New...